Routine cleaning and maintenance of outdoors microcement

The cleaning and maintenance of outdoors cement agglomerates, such as terrazzo and cement tiles require scheduled routine maintenance rules to avoid degradation of the treated and untreated material and contamination with biological scale (e.g. mould, moss, lichen, etc.)

Where and when

Where:

  • This cleaning and routine maintenance system is designed for cement floors placed outdoors, such as terrazzo and cement tiles.

When:

  • For routine cleaning, use the product ECOMARBEC.
  • For periodic preventive cleaning, use the product ALGANET, which prevents the formation of biological incrustations.
  • For a nourishing treatment of the cement surface, PAV05 wax is applied.
Frequency of use:
  • ECOMARBEC is used for routine cleaning.

 

  • ALGANET is used for preventive cleaning: to prevent the formation of biological fouling.
      • This cleaning is especially recommended in very humid areas with little sunlight to prevent the formation of algae mats.
      • It is recommended to apply ALGANET every 12 to 24 months in spring in order to decontaminate the surface from any micro biological incrustations formed during the winter period.
      • ALGANET is applied before PAV05.

 

  • PAV05 is applied once every 12/24 months to restore any deterioration of the product itself due to wear and weathering.
      • The application of PAV05 serves to reinstate the treatment carried out in the previous 12/24 months and restore the protective and aesthetic characteristics of the initial treatment.

Performance and consumption

ECOMARBEC:

  • is a product that does not contain caustic soda, ammonia, perfumes, dyes and solvents;
  • cleans, degreases, sanitizes the surfaces in cotto, stone, marbles, cement and synthetic terrazo, porcelain tiles and other ceramic materials;
  • acts by dissolving the fatty substances, making them easily removable;
  • can be used for manual and mechanical washing (eg washer dryer, pressure washer).

ALGANET:

  • helps remove the blackening left by microorganisms (eg residues of algae, moss, and lichens), residues of leaves and flowers, animal excrement, urine, etc . , through its action and the mechanical rubbing;
  • can also be applied on treated surfaces;
  • has a deep and gradually effective action over time;
  • can also be used for cleaning tents and tarpaulins in pvc and other external plastic materials;
  • is effective even at low temperatures;
  • once dry, is no longer dangerous for the vegetation;
  • can be applied several times on very dirty surfaces and in the presence of lichens that are difficult to remove, without damaging the stone materials.

Pay attention that when applying ALGANET in its liquid state it does not come into direct contact with soil, plants, fabrics, metals, and wood.
Do not use other acid products when applying ALGANET.

PAV05:

  • is a water-based, odourless, non-hazardous and easy-to-use product;
  • increases the protection of materials treated with water-repellent primer and extends their life;
  • has excellent dirt-repellent, anti-degradation and weathering properties;
  • drastically reduces algae growth on surfaces;
  • brings out the colour of the material and does not form a thick film on the surface, leaving the material with good vapour permeability;
  • makes surfaces easier and quicker to clean and is maintained over time through routine cleaning with ECOMARBEC cleaner and application of PAV05 once or twice a year.
Torna all'intro
Step 1 di 3

Routine cleaning

• It can be used pure or diluted in water.
Dosage:

Dilute 1 part of ECOMARBEC in 2 equal parts of water: for strong degreasing washes, to remove substantial residues of greasy dirt (food/mineral oils, greases and residues of stubborn dirt);
• Spread ECOMARBEC on the floor with a soft cloth and leave for a few minutes;
• Rub the surface with sponges or plastic fiber pads or discs;
• Finally rinse everything with clean water;

Dilute 180-250cc of ECOMARBEC in 5 litres of water: for periodic degreasing;
• Apply as a normal detergent with a microfiber cloth. In this dilution it is also possible to use scrubbing machines;

Dilute 50-100cc of ECOMARBEC in 5 liters of water: for daily cleaning of all surfaces;
• Apply as a normal detergent with a microfiber cloth. In this dilution it is also possible to use scrubbing machines.

Yield: • depending on concentrations used.

Prodotti e accessori

ECOMARBEC

Detergent for the ordinary and/or extraordinary cleaning of all floors. It cleans, degreases and sanitizes surfaces and does not attack materials. Biodegradable, does not contain perfumes and hypoallergenic.

SOFT MICROFIBER CLOTH | MARBEC

Ideal for washable tops such as glass, mirrors, plastic, stainless steel, chrome, ceramic and enamel surfaces. Particularly strong, tear-resistant edge. Can be used for all environments. Measures 40x40 cm.

MICRO-ACTIVE MICROFIBER CLOTH WITH VELCRO ATTACHMENT | FILMOP

Ideal for all smooth surfaces with a medium level of dirt. Can be used with all tools  for dusting, washing, waxing featuring Velcro profiles. Also useful for disinfecting smooth interior floors (hotels, homes, offices, hospitals) with a medium to low level of dirt.

Torna all'intro
Step 2 di 3

Annual cleaning for humid areas

Extraordinary cleaning of surfaces contaminated by organic scale:
• Dissolve in a clean plastic bucket 800 gr of ALGANET in 10 liters of water mixing for a few minutes. The solution thus obtained must be used within 3-4 hours;
• Can be applied with brush, sponge, soft cloth or broom;
• Thoroughly wet the surface to be treated by rubbing the product with hard brush or brown buffer pad and leave until drying (normally 12/24 hours);
• Repeat washing if necessary;
• Finally rinse with plenty of water or pressure washer.

Extraordinary cleaning on surfaces heavily contaminated by biological incrustations (especially lichens):
• It is advisable to carry out a preliminary washing with a pressure washer or rub the surface with water and BROWN BUFFER PAD, so as to remove the surface patina as much as possible .
• Dissolve in a clean plastic bucket 800 gr of ALGANET in 10 liters of water mixing for a few minutes. The solution thus obtained must be used within 3-4 hours;
• Can be applied by brush, sponge, soft cloth or broom;
• Thoroughly wet the surface to be treated by rubbing the product with hard brush or brown buffer pad and leave until drying (normally 12/24 hours);
• Next, the surface should be rinsed with a solution of water and ECOMARBEC (diluted to 20/30%), so as to degrease and remove the residues of dirt and product ALGANET in depth ;
• During the rinsing phase it is recommended to rub the surface with hard brushes, discs, brown buffer pads in order to facilitate the removal of degraded dirt;
• Repeat washing if necessary;
• Finally rinse with plenty of water or pressure washer.

Yield: • with 800g of powder are prepared about 10 liters of cleaning solution (average consumption of the diluted product 1 lt / 5-7 sqm).

Prodotti e accessori

External floor cleaning ALGANET | MARBEC

ALGANET

Concentrated stain remover in powder specifically for the deep cleaning of external stone floors. It cleans and helps to remove algae, moss, and other encrustations of organic origin from surfaces.

BROWN BUFFER PAD MARBEC | Very Abrasive

Sponge with strong abrasive properties, for strong descaling and de-waxing of stone materials.

BROWN DISC MARBEC | Very Abrasive

The BROWN DISC is composed of a polyester structure with a high density of resin and mineral. It has high resistance to acid or alkaline substances, it is used wet to carry out manual dewaxing and descaling washes. Ideal for: Descaling cleaning on cotto and porcelain tiles; Dewaxing cleaning on cotto, stone and cement.

Torna all'intro
Step 3 di 3

Maintenance wax application

• It is used pure;
• Shake well before use;
• Distribute the product with spreading fleece, soft cloth or sponge. It should be spread in a thin layer by wetting the surface homogeneously and without leaving build-ups;
• Dries quickly, generally in 2-3 hours;
• Apply the second coat as soon as the first one is dry.
• Protect freshly treated surfaces from rain before 6-8 hours from application.
• Do not apply on very hot or sunlight exposed surfaces, windy days or temperatures below 5 ºC.

Application types:
• 1 coat: on absorbent surfaces;
• 2 coats: on very rough surfaces.

Yield: • Approximately with 1 lt / 8-14 sqm.

Prodotti e accessori

PAV05

Protective finishing anti-dirt, anti-degradation wax resistant to atmospheric agents and trampling for cotto, stones and terrazo.

FLEXIBLE WAX APPLICATOR FLEECE | FILMOP

Perfect for distributing wax, even on hard-to-reach surfaces, as it can be attached to the telescopic handle.

SOFT MICROFIBER CLOTH | MARBEC

Ideal for washable tops such as glass, mirrors, plastic, stainless steel, chrome, ceramic and enamel surfaces. Particularly strong, tear-resistant edge. Can be used for all environments. Measures 40x40 cm.

ADVICE FROM THE TECHNICIAN

Depending on your problem, check again the steps recommended by the technician and select the right products for you! For all your needs, do not hesitate to contact us, either by e-mail or on WhatsApp.

9.06€

ECOMARBEC

Detergent for the ordinary and/or extraordinary cleaning of all floors. It cleans, degreases and sanitizes surfaces and does not attack materials. Biodegradable, does not contain perfumes and hypoallergenic.

External floor cleaning ALGANET | MARBEC

19.43€

ALGANET

Concentrated stain remover in powder specifically for the deep cleaning of external stone floors. It cleans and helps to remove algae, moss, and other encrustations of organic origin from surfaces.

4.36€

BROWN BUFFER PAD MARBEC | Very Abrasive

Sponge with strong abrasive properties, for strong descaling and de-waxing of stone materials.

12.03€

BROWN DISC MARBEC | Very Abrasive

The BROWN DISC is composed of a polyester structure with a high density of resin and mineral. It has high resistance to acid or alkaline substances, it is used wet to carry out manual dewaxing and descaling washes. Ideal for: Descaling cleaning on cotto and porcelain tiles; Dewaxing cleaning on cotto, stone and cement.

16.45€

FLEXIBLE WAX APPLICATOR FLEECE | FILMOP

Perfect for distributing wax, even on hard-to-reach surfaces, as it can be attached to the telescopic handle.

2.20€

SOFT MICROFIBER CLOTH | MARBEC

Ideal for washable tops such as glass, mirrors, plastic, stainless steel, chrome, ceramic and enamel surfaces. Particularly strong, tear-resistant edge. Can be used for all environments. Measures 40x40 cm.

Free shipping from 100€ - Delivery in 5-6 working days
Secure payment
Whatsapp Contact: +39 334 8578502